Dangerous COMPRESSOR Operator's Manual download pdf (Page 14)

#2275OPERATOR’SMANUAL 14

Monthly

Inspectairsystemforleaksbyapplyingsoapywatertoalljoints.Tightenthesejointsifleaksare

discovered.

6 Months (or after 250 hours of operation - whichever comes rst)

ChangeAirCompressorOil.

Note: ChangetheoilmoreoftenifyourAirCompressorisusednearpaintsprayingoperationsor

industyenvironments.

Checking the Air Compressor Oil

1. PlaceyourAirCompressoronalevelsurface.TheoillevelshouldbeatthereddotontheOilSight

Glass.

2. Ifoillevelislow,removeOilBreatherCapandaddenoughoiltobringtheoilleveltothereddoton

theOilSightGlass.

Changing the Air Compressor Oil

Note: ThiscompressorusesonlySAE5W-30motoroil.

1. RemovetheOilSightGlassbyturningcounterclockwisewithwrench.

Note: OilwillbegintodrainastheOilSightGlassisloosened.Makesureafunnelandoilpanare

inplaceBEFORElooseningtheOilSightGlass.

2. OncetheOilSightGlassisremoved,tiltyourAirCompressorforwardstoallowalltheoilto

drainoutoftheCrankcase.

3. Oncetheoilisdrained,replacetheOilSightGlassandsecurelytighteninplacewithawrench.

BecarefulnottoovertightentheOilSightGlass,asthiscoulddamagetherubberseal.

4. PlaceyourAirCompressoronlevelsurface.

5. RemovetheOilBreatherCap.

6. Slowlypourtheoilintotheoilllhole,untiltheoillevelrisestothecenterofthereddotonthe

OilSightGlass.

7. InstalltheOilBreatherCapintotheoilllhole.

8. AlwaysinspectAirCompressorbeforeuse,andmakesureitisingoodworkingcondition.Use

compressedairtocleanthemachinewherepossible.

1 2 ... 9 10 11 12 13 14 15 16 17 18 19

No comments

Dangerous COMPRESSOR Operator's Manual Page 14